THE HEKTOGRAPH.
For obtaining multiple copies of writing, the apparatus called the
Hektograph or Papyrograph has been extensively adopted. In general
terms it consists of a tray filled with a jelly like composition. Any
imprint made upon the surface with aniline ink can be transferred to
paper by simple pressure. The tray filled with composition is called
the tablet. It is thus prepared.
The tray may be made of tin or even of pasteboard or paper, and should
be about one half an inch deep. It may be of any size, according to the
work it is to do. The composition is made from the best gelatine and
glycerine. One ounce by weight of gelatine is soaked over night in cold
water, and in the morning the water is poured off, leaving the swelled
gelatine. Six and one-half fluid ounces of glycerine are now heated
to about 200 F. (93 C.) on a water bath preferably, and the gelatine
is added thereto. The heating is continued for several hours. This
operates to expel the water and to give a clear glycerine solution of
gelatine.
The composition is then poured into the tray, which must be perfectly
level in order to obtain a surface nearly even with the edge. It is
then covered so as to keep off the dust. The cover of course must not
come in contact with the smooth surface. In six hours it will be ready
for use.
The original copy that is to be reproduced is made upon ordinary paper
in aniline ink. One formula for the ink reads as follows: Aniline
violet or blue (2 R B or 3 B) 1 oz., hot water 7 fluid oz.; dissolve.
After cooling add alcohol 1 fluid oz. and glycerine ¼ fluid oz., a few
drops of ether and a drop of carbolic acid. Keep in a corked bottle.
Other formulæ are given in chapter XVII.
The writing is executed with an ordinary steel pen. The lines should be
rather heavy so as to show a greenish color by reflected light.
The surface of the pad is slightly moistened with a wet sponge and
is allowed to become nearly dry. The paper is then laid upon it and
smoothed down. This is best done by placing a second sheet over it and
rubbing this with the hand. No air bubbles must remain between the copy
and the tablet, and the paper must not be shifted.
It is allowed to remain for a minute or less and is then raised by one
corner and stripped from the gelatine surface. It will have left the
reversed copy of its inscription perfectly reproduced upon the tablet.
At once a piece of ordinary writing paper of the desired size and
quality is laid upon the tablet, smoothed down, and stripped off,
when it will be found to have taken with it a complete copy of the
inscription or writing. This is repeated over and over again with
another sheet of paper, until the ink on the pad is exhausted. Fifty or
more good copies can be thus obtained.
[Illustration: THE HEKTOGRAPH.]
As soon as the work is completed the remains of the ink should be
washed off with a moist sponge and the tablet, after drying a little,
will be ready for a second operation.
Some practice is required to ascertain the proper strength of the
writing and degree of wetness of the surface. When the gelatine surface
becomes impaired it can be remelted in a water bath if it is not too
dark from absorption of ink.
_French Ministry of Public Work Formula._--Glue 100 parts, glycerine
500 parts, finally powdered kaolin or barium sulphate 25 parts, water
375 parts. Use a little hydrochloric acid in the water for washing off
the pad after use.
_Hektograph Sheets._--Four parts of glue are soaked in five parts of
water and three parts of ammonia until soft. It is then heated and
there is added to it three parts of sugar and eight parts of glycerine.
The mixture is applied to blotting paper. This is saturated with it,
and successive coats added until a smooth surface is produced on one
side. This is the side for reproduction. It is used like the regular
tablet except that it is claimed that sponging off the writing is not
necessary. Owing to the capillary action developed by the blotting
paper it is supposed to be self-cleaning by standing.